English
Motor Matic is a motor that is the easiest to use and most in our homeland. please note that the motor also takes care of very sensitive, just like a computer that also takes care of sensitive anyway. because everything is just a tool used by humans is limited. if treated then it will be a long tool age, even if without any treatment contrary, it devastated the tool quickly.
at this point I will give insights into the treatment of motor matic specifically for kick starter motors honda beat. if they say Indonesia is often referred to pause the motor. Kick starter is very useful once on each motor, if the primary starter (electric starter) is damaged, then interrupts motorlah last for motor matic way to light up. because unlike the motor manuals that have teeth which can also be used as a starter to ignite, motor matic certainly not have it. therefore, if the starter motor matic is damaged then, no one will terpakailah matic motorcycle.
tips fix the kick starter / pause motors that are difficult or hard, are as follows:
first unloading bolts on the kick / pause motors. then unloading all screws key size 8, beware there are two screws covered by a plastic body, after which it will appear in the image below.
note that under carburator filter box, there is an armature that is connected with the electric starter, sometimes the motor armature will move if electric starter is pressed. nah here to note as well as many a crust of dirt and should be cleaned, if I use a little spray chain lube on the connection gear toward the main gear. This serves to accelerate the performance of the electric starter in moving the main engines. install it again last connection to the pit below.
post carefully and then we go to the kick starter or a part-stream of the motor. open all the screw with a Phillips screwdriver or (+), do not forget to clean everything.
after everything with a clean open air compressor or with a dry cloth. see below, sometimes here was the brain starts to think out loud. if you want to open / release section below about how to reinsert the kick / td pause to the back of the picture and then move gradually and while pulling a small part is to completely uprooted. here I wash again with a dry cloth and spray a little chain lube until all clean and smooth. then reinstall it.
how to set it up the same way as dismantling it. be seen sometimes not all there is a smooth gear. if part of the image below, I do not put all the gear in full because there are about gear to the three little bit broken. therefore I'm exaggerating a gear position kick / pause is to avoid traffic jams as before dismantling. I lubricate the bit with chain lube spray again on all the gear in order to facilitate the performance of gear.
after all is installed again, then finished matic maintenance work and be ready on the sidelines back.
in my case. These motors can not be a starter through electric or with a pause. therefore, such a case could be a reference for those who have difficulty in all respects starter.
the possibility of several things the symptoms of damage to the motor matic:
broken electric starter. please check the battery, the relay of the battery, if all new okay to the dismantling as described above. if the battery is exhausted check or replace the battery kiprok possibility tercharge not perfect because of damage to the components kiprok. that the means of checking the relay can download straight jumper cables to the electric starter motor armature with the cable from the battery. superbly located not far from the battery that is charged + (positive). if there is a significant movement of the relay is broken. but be careful sometimes not on a relay that was broken but the battery. if the relay is no sound (tek, tek, tek) when pressing the electric starter means the damage is only on battery power shortages. how to charge the battery that is so, can be fitted to the motor while the other, or at a charge to the battery repair services etc.
kiprok damaged. overdrawn or soak symptoms battery, all lights many charred. how to replace it with a new one. how to check the damage kiprok namely by removing the battery from the motorcycle, and try to crank or a kick starter. if the motor turns on the kiprok good, if not illuminated, ugly.
Busi damaged. if all engines are fine, the second starter okay, but still will not turn on, please check the spark plug part, because with this tool to get ignition engine. replace with a new one if it really is a broken tool, because there are two things that make the engine would not start, namely Busi, and another CDI
CDI damaged. just as the spark plug if it is damaged then replace it with a new one.
Thus glance insight to your need. if there are still many shortcomings please comment, thank you. may be useful
Indonesia
Motor Matic merupakan motor yang paling mudah digunakan dan paling banyak di tanah air kita. perlu diketahui bahwa motor juga butuh perawatan yang sangat sensitif, sama seperti komputer yang juga membutuhkan perawatan yang sensitif pula. karena semua yang digunakan oleh manusia hanyalah alat yang terbatas. jika dirawat maka alat itu akan panjang usianya, bahkan sebaliknya kalo tanpa adanya perawatan, maka rusaklah alat tersebut dengan cepat.
Motor Matic is a motor that is the easiest to use and most in our homeland. please note that the motor also takes care of very sensitive, just like a computer that also takes care of sensitive anyway. because everything is just a tool used by humans is limited. if treated then it will be a long tool age, even if without any treatment contrary, it devastated the tool quickly.
at this point I will give insights into the treatment of motor matic specifically for kick starter motors honda beat. if they say Indonesia is often referred to pause the motor. Kick starter is very useful once on each motor, if the primary starter (electric starter) is damaged, then interrupts motorlah last for motor matic way to light up. because unlike the motor manuals that have teeth which can also be used as a starter to ignite, motor matic certainly not have it. therefore, if the starter motor matic is damaged then, no one will terpakailah matic motorcycle.
tips fix the kick starter / pause motors that are difficult or hard, are as follows:
first unloading bolts on the kick / pause motors. then unloading all screws key size 8, beware there are two screws covered by a plastic body, after which it will appear in the image below.
note that under carburator filter box, there is an armature that is connected with the electric starter, sometimes the motor armature will move if electric starter is pressed. nah here to note as well as many a crust of dirt and should be cleaned, if I use a little spray chain lube on the connection gear toward the main gear. This serves to accelerate the performance of the electric starter in moving the main engines. install it again last connection to the pit below.
post carefully and then we go to the kick starter or a part-stream of the motor. open all the screw with a Phillips screwdriver or (+), do not forget to clean everything.
after everything with a clean open air compressor or with a dry cloth. see below, sometimes here was the brain starts to think out loud. if you want to open / release section below about how to reinsert the kick / td pause to the back of the picture and then move gradually and while pulling a small part is to completely uprooted. here I wash again with a dry cloth and spray a little chain lube until all clean and smooth. then reinstall it.
how to set it up the same way as dismantling it. be seen sometimes not all there is a smooth gear. if part of the image below, I do not put all the gear in full because there are about gear to the three little bit broken. therefore I'm exaggerating a gear position kick / pause is to avoid traffic jams as before dismantling. I lubricate the bit with chain lube spray again on all the gear in order to facilitate the performance of gear.
after all is installed again, then finished matic maintenance work and be ready on the sidelines back.
in my case. These motors can not be a starter through electric or with a pause. therefore, such a case could be a reference for those who have difficulty in all respects starter.
the possibility of several things the symptoms of damage to the motor matic:
broken electric starter. please check the battery, the relay of the battery, if all new okay to the dismantling as described above. if the battery is exhausted check or replace the battery kiprok possibility tercharge not perfect because of damage to the components kiprok. that the means of checking the relay can download straight jumper cables to the electric starter motor armature with the cable from the battery. superbly located not far from the battery that is charged + (positive). if there is a significant movement of the relay is broken. but be careful sometimes not on a relay that was broken but the battery. if the relay is no sound (tek, tek, tek) when pressing the electric starter means the damage is only on battery power shortages. how to charge the battery that is so, can be fitted to the motor while the other, or at a charge to the battery repair services etc.
kiprok damaged. overdrawn or soak symptoms battery, all lights many charred. how to replace it with a new one. how to check the damage kiprok namely by removing the battery from the motorcycle, and try to crank or a kick starter. if the motor turns on the kiprok good, if not illuminated, ugly.
Busi damaged. if all engines are fine, the second starter okay, but still will not turn on, please check the spark plug part, because with this tool to get ignition engine. replace with a new one if it really is a broken tool, because there are two things that make the engine would not start, namely Busi, and another CDI
CDI damaged. just as the spark plug if it is damaged then replace it with a new one.
Thus glance insight to your need. if there are still many shortcomings please comment, thank you. may be useful
Indonesia
Motor Matic merupakan motor yang paling mudah digunakan dan paling banyak di tanah air kita. perlu diketahui bahwa motor juga butuh perawatan yang sangat sensitif, sama seperti komputer yang juga membutuhkan perawatan yang sensitif pula. karena semua yang digunakan oleh manusia hanyalah alat yang terbatas. jika dirawat maka alat itu akan panjang usianya, bahkan sebaliknya kalo tanpa adanya perawatan, maka rusaklah alat tersebut dengan cepat.
pada saat ini saya akan memberi wawasan tentang perawatan motor matic khususnya untuk kick starter motor honda beat. kalo kata orang indonesia sering disebut juga dengan selaan motor. Kick starter ini sangat berguna sekali pada setiap motor, kalo starter primer (electric starter) rusak, maka menyela motorlah cara terakhir bagi motor matic untuk menyala. soalnya tidak seperti motor manual yang mempunyai gigi yang bisa juga digunakan sebagai starter untuk menyala, motor matic tentu tidaklah mempunyai hal tersebut. oleh karena itu jika kedua starter pada motor matic ini rusak maka, tak kan terpakailah motor matic tersebut.
tips memperbaiki kick starter / selaan motor yang susah ataupun keras, adalah sbb:
pertama kali bongkar baut pada bagian kick/ selaan motor. lalu bongkar semua baut ukuran kunci 8 , hati-hati ada 2 baut yang tertutup oleh body berbahan plastik, setelah itu akan muncul gambar di bawah ini.
perhatikan yang di bawah box filter carburator, di situ ada dinamo yang tersambung dengan electric starter, kadang-kadang dinamo motor ini akan bergerak jika electric starter ditekan. nah di sini perlu diperhatikan juga karena banyak kerak kotoran dan harus dibersihkan, kalo saya menggunakan sedikit semprotan chain lube pada sambungan gear yang menuju gear utama. ini berfungsi untuk mempercepat kinerja dari electric starter dalam menggerakkan mesin utama. pasang lagi sambungan tadi ke lubang di bawah ini.
pasang dengan seksama lalu kita menuju ke bagian kick starter atau bagian sela motor. buka semua sekrup dengan obeng kembang atau (+), jangan lupa untuk membersihkan semuanya.
setelah terbuka bersihkan semuanya dengan angin kompressor atau dengan lap kering. lihat di bawah ini, kadang di sini lah otak mulai berpikir dengan keras. jika ingin membuka / melepaskan bagian di bawah ini caranya dengan memasukkan kembali kick / selaan td ke bagian belakang dari gambar lalu gerakkan sedikit demi sedikit lalu sambil tarik bagian kecil tersebut sampai tercabut seluruhnya. di sini saya bersihkan kembali dengan lap kering dan semprot sedikit chain lube sampai semua bersih dan licin. setelah itu pasang kembali.
cara memasangnya sama seperti cara membongkarnya. perlu dilihat kadang-kadang tidak semua gear ada yang mulus. kalo bagian gambar di bawah ini saya tidak memasang semua gear secara full karena ada sekitar gear yang ke tiga sedikit agak rusak. oleh karena itu saya lebihkan posisi gear kick / selaan ini agar tidak macet seperti sebelum dilakukan pembongkaran. saya lumasi sedikit dengan semprotan chain lube lagi pada semua gear agar memudahkan kinerja gear.
setelah semua terpasang lagi, maka selesailah pekerjaan perawatan motor matic ini dan siap di sela kembali.
pada kasus saya. motor ini tidak dapat starter melalui electric ataupun dengan selaan. oleh karena itu, hal demikian bisa jadi merupakan referensi bagi anda yang mempunyai kesulitan dalam semua hal starter.
kemungkinan beberapa hal gejala kerusakan pada motor matic :
- rusak electric starter. silahkan cek aki, relay dari aki, jika semua oke baru ke bagian pembongkaran seperti di atas. kalau aki soak periksa atau ganti kiprok kemungkinan aki tidak tercharge sempurna karena kerusakan pada komponen kiprok. kalau cara pengecekan relay bisa dengan men jumper langsung kabel menuju dinamo motor electric starter dengan kabel dari aki. biasa terletak tidak jauh dari aki yang bermuatan + (positif). jika ada pergerakan berarti relay rusak. tapi hati-hati kadang-kadang bukan pada relay yang rusak akan tetapi pada aki. jika pada relay ada suara (tek, tek, tek) ketika menekan electric starter berarti itu kerusakan hanya pada kekurangan daya listrik aki. cara mencharge aki yang demikian, bisa dengan dipasang sementara ke motor lain, atau di charge ke jasa perbaikan aki dll.
- rusak kiprok. gejalanya aki tekor atau soak, semua lampu banyak yang gosong. caranya ganti dengan yang baru. cara cek kerusakan kiprok yaitu dengan melepas aki dari motor, dan cobalah engkol atau kick starter. jika motor menyala maka kiprok bagus, jika tidak menyala maka jelek.
- rusak Busi. jika semua mesin baik-baik saja, kedua starter oke, tapi masih tak mau menyala, silahkan cek bagian busi, karena dengan alat ini mesin mendapatkan pengapian. ganti dengan yang baru jika benar-benar alat ini yang rusak, karena ada 2 hal yang menjadikan mesin tidak mau menyala, yaitu Busi, dan satu lagi CDI
- rusak CDI. sama seperti busi jika rusak maka ganti dengan yang baru.
demikian sekilas wawasan untuk anda yang memerlukan. jika masih banyak kekurangan silakan berkomentar, terima kasih. semoga berguna
No comments:
Post a Comment